The 40 kW fuel of biogas generator set is mainly natural gas. Natural gas is a gaseous fossil fuel with multi-component mixture. Its important component is n-alkanes, including methane, while a large number of ethane, propane and butane. It is important in kerosene, natural gas, coal and shale. No waste gas, waste water, extinguished coal. Next, Shandong HuaQuan power introduces the commissioning steps of biogas generator set.

1、查抄沼氣發電機組40千瓦局部的外導體銜接沒有斷線，此時用電壓表丈量D+點有無電壓，并察看充電指示燈能否亮堂。

1. Check that the connection of the external conductor of the 40 kW biogas generator set is not broken. At this time, measure the voltage at point D + with a voltmeter and see whether the charging indicator light is on.

沼氣發電機組40千瓦

Biogas generator set 40 kw

2、將鑰匙門“開”的地方拉上去，但不啟動沼氣發電機組，此時用電壓表丈量電壓能否在D點和察看充電指示燈和亮堂。

2. Pull the key door "open", but do not start the biogas generator set. At this time, use a voltmeter to measure whether the voltage is at point D and check whether the charging indicator light is on.

3、啟動沼氣發電機組，該沼氣發電機組在B點用電壓表丈量電壓，應到達以下值加減油門電壓24V體系電壓27V以上電壓高于12燃氣發電機組V的13V體系，而有一點點的變革0.1～0.2V。

3. Start the biogas generator set. The voltage of the biogas generator set shall be measured with a voltmeter at point B, which shall reach the following value. Add or subtract the throttle voltage 24V system voltage above 27V, and the voltage is higher than the 13V system of 12 gas generator set V, with a little change of 0.1 ~ 0.2V.

4、翻開局部負荷，如燈12V體系電壓超越13V同時加減油門電壓24V體系電壓27V或中度的變革在0.2～0.4V。

4. Turn over the local load. For example, the lamp 12V system voltage exceeds 13V, and increase or decrease the throttle voltage 24V, and the system voltage 27V or moderate change is 0.2 ~ 0.4V.

5、翻開空調，燈光等重要電氣體系電壓為13V12V以上的油門，而減法，電壓24V體系27V以上的電壓有較大水平的變革0.5～1V。

5. Turn on the accelerator with the voltage above 13v12v in air conditioning, lighting and other important electrical systems, while the subtraction shows that the voltage above 27V in 24V system has a great change of 0.5 ~ 1V.

沼氣發電機組40千瓦無電壓輸入，能夠作為一種辦法來查抄，為新一代發電機勵磁D點，如27系列，23系列，29系列，19系列電池正極引線從2.5平方毫米線，在沼氣發電機組起動后，即時單擊點D的另一端，然后將電壓表丈量的輸入電壓能否在B點，沼氣發電機組肯定車輛同時充電指示燈線路短路時無電壓輸入，那么有沒有沼氣發電機組故障。

The 40 kW no voltage input of the biogas generator set can be used as a way to check whether the input voltage measured by the voltmeter can be at point B after the biogas generator set is started, such as the positive lead of 27 series, 23 series, 29 series and 19 series batteries from the 2.5 mm2 line, If there is no voltage input when the vehicle charging indicator line is short circuited, is there a fault of the biogas generator set.