本文將為大家簡單的介紹關于焦化發電機組在安裝時須注意的六個要點，一起來看看看吧。

This article will briefly introduce the six points that should be paid attention to when installing the coking generator set. Let's have a look.

1、安裝地點需通風良好，發電機端應有足夠的進風口，焦化機端應有良好的出風口。出風口面積應大于水箱面積1.5倍以上。

1. The installation site shall be well ventilated. There shall be sufficient air inlets at the generator end and good air outlets at the coking machine end. The air outlet area shall be more than 1.5 times of the water tank area.

2、安裝地的周?chē)鷳３智鍧?，避免在附近放置能產生酸性、堿性等腐蝕性氣體和蒸汽的物品。有條件的應配置滅火裝置。

2. The surroundings of the installation site shall be kept clean, and articles that can generate corrosive gases and vapors such as acid and alkaline shall be avoided from being placed nearby. Fire extinguishing devices shall be provided if conditions permit.

3、在室內使用，須將排煙管道通導室外，焦化發電機管徑須≥消音器的出煙管直徑，所接之管路的彎頭不宜超過3個，以保證排煙暢通，并應將管子向下傾斜5-10度，避免雨水注入；若排氣管時垂直向上安裝的，則須加裝防雨罩。

3. For indoor use, the smoke exhaust pipe must be connected to the outside. The pipe diameter of the coking generator must be ≥ the diameter of the exhaust pipe of the silencer. The elbows of the connected pipes should not be more than 3 to ensure smooth smoke exhaust. The pipes should be inclined downward by 5-10 degrees to avoid rainwater injection; If the exhaust pipe is installed vertically, a rain cover must be installed.

4、基礎采用混凝土時，在安裝時須用水平尺測其水平度，使機組固定于水平的基礎上。機組與基礎之間應有專用防震墊或用底腳螺栓。

4. When the foundation is made of concrete, the levelness shall be measured with a level ruler during installation to fix the unit on the horizontal foundation. There shall be special shockproof pads or foot bolts between the unit and the foundation.

5、機組外殼須有可靠的保護接地，對需要有中性點直接接地的發電機，則須由人員進行中性接地，并配置防雷裝置，嚴禁利用市電的接地裝置進行中性點直接接地。

5. The unit shell must have reliable protective grounding. For the generator that needs to be directly grounded at neutral point, the neutral grounding shall be conducted by professional personnel and equipped with lightning protection device. It is strictly prohibited to use the grounding device of mains power for direct grounding at neutral point.

6、發電機與市電的雙向開關須十分可靠，以防倒送電。雙向開關的接線可靠性需經過當地供電部門的檢驗認可。

6. The two-way switch between the generator and the mains must be very reliable to prevent reverse power transmission. The wiring reliability of the two-way switch shall be inspected and approved by the local power supply department.

發電機組在安裝時需要注意的六大要點上述已經講解完畢了，希望能夠給您好的幫助，更多事項就來我們網站http://m.elmasticar.com咨詢吧！

The six main points that should be paid attention to during the installation of the generator set have been explained. I hope you can help me. For more matters, please visit our website http://m.elmasticar.com Consult!