燃氣發電機組雖然節能環保，但是對操作環境、配套設備要求較高，隱患較大，稍不注意，就有可能釀成災禍。因此，在使用燃氣發電機組的時候除了要遵守以下安全規定外，還要根據具體情況，制定安全操作規程，并嚴格遵守。

Although the gas-fired power generation unit is energy-saving and environmental friendly, it has high requirements on the operating environment and supporting equipment, and has great hidden dangers. If you do not pay attention to it, it may lead to disasters. Therefore, in addition to the following safety regulations, safety operation regulations shall be formulated and strictly observed according to the specific conditions when using the gas-fired generator set.

在燃氣發電機組發動機使用前，應根據具體使用的環境和條件，選用適當規格的然氣、機油和冷卻液。選用恰當與否，對燃氣發電機組的發動機的性能和使用壽命有很大的影響。

Before the use of the gas generator set engine, the natural gas, oil and coolant with appropriate specifications shall be selected according to the specific use environment and conditions. Whether the selection is appropriate or not has a great impact on the performance and service life of the engine of the gas generator set.

1、燃氣發電機組使用然氣的要求

1. Requirements for using natural gas for gas generator set

燃氣發動機的燃料以然氣為主，主要有油田伴生氣、液化石油氣、沼氣、瓦斯等可燃性氣體。所用的氣體應通過干燥脫水，達到無游離水、原油和輕質油。

The fuel of gas engine is mainly natural gas, mainly including oil field associated gas, liquefied petroleum gas, biogas, gas and other combustible gases. The gas used shall be dried and dehydrated to be free of free water, crude oil and light oil.

2、燃氣發電機組所用的機油

2. Oil for gas generator set

機油是用來潤滑燃氣發動機的運動件并對這些運動件起到冷卻散熱、帶走雜質和防止銹的作用。其品質的好壞除對燃氣發動機的性能和使用壽命有影響外，對機油的使用期限有一定的影響。為此，應根據燃氣發動機的使用環境溫度來選適當的機油。燃氣發動機盡可能使用燃氣發動機專用機油。

The engine oil is used to lubricate the moving parts of the gas engine and to cool and dissipate heat, remove impurities and prevent rust. In addition to the performance and service life of the gas engine, the quality of the oil has a certain impact on the service life of the engine oil. Therefore, the proper engine oil should be selected according to the operating environment temperature of the gas engine. Special engine oil for gas engine shall be used as much as possible.

3、燃氣發電機組使用的冷卻液

3. Coolant used for gas generator set

用于冷卻系統的直接冷卻發動機的冷卻液通常使用清潔的淡水，雨水或經澄清的河水為宜.當燃氣發動機在低于0度的環境條件使用時，應嚴防冷卻液凍結，致使零件凍裂?？筛鶕囟葋?lái)配用適當凝點的防凍液或在起動前加注熱水，但停車后應立即放水。

Clean fresh water, rain water or clarified river water is usually used as the coolant for the direct cooling engine of the cooling system When the gas engine is used under the environmental conditions below 0 ℃, the cooling liquid shall be strictly prevented from freezing, which may cause the parts to freeze. Antifreeze with proper freezing point can be added according to the temperature or hot water can be added before starting, but water shall be drained immediately after shutdown.

小編在此提醒大家，燃氣發電機組在使用過程中存在一定安全隱患，需要在平時使用時多加注意，嚴格按照規章制度操作。關注我們http://m.elmasticar.com，了解更多！

The editor hereby reminds you that there are certain potential safety hazards in the use of gas-fired generating units, and it is necessary to pay more attention to them during normal use and operate in strict accordance with the rules and regulations. Follow us http://m.elmasticar.com Yes, learn more!