What's the difference between gas generator set and diesel generator set in use? How to choose? Many people don't know what kind of generator set is needed. Today we will analyze the advantages of various generator sets for your convenience.

　　燃氣發電機組和柴油發電機組的選擇取決于需求

　　The choice of gas and diesel generators depends on demand

　　1.使用

　　1. Use

　　柴油發電機組:應急電源

　　Diesel generator set: emergency power supply

　　燃氣發電機組:通用電源

　　Gas generator set: general power supply

　　2.結構。

　　2. Structure.

　　柴油發電機組:發動機、發電機、控制系統、供油系統。

　　Diesel generator set: engine, generator, control system, oil supply system.

　　氣體發電機組:發動機、發電機、控制器、選配穩壓過濾裝置、氣液(汽液)分離裝置、化油器等。

　　Gas generator set: engine, generator, controller, pressure stabilizing filter, gas-liquid (vapor-liquid) separation device, carburetor, etc.

　　3.燃料

　　3. Fuel

　　柴油發電機組:柴油

　　Diesel generator set: Diesel

　　燃氣發電機組:天然氣

　　Gas generator set: natural gas

　　4. 單位選擇

　　4. Unit selection

　　柴油發電機組:根據負荷要求和當地運行環境而定

　　Diesel generator set: according to load requirements and local operation environment

　　:氣體發生器的用戶在選擇天然氣發電機組,應根據當地資源條件選擇合適的燃氣來源,然后,燃氣成分分析和計算的低熱值燃氣,確定相關的物理參數和氣體環境狀態參數,如氣體組分、流量、壓力、溫度、相對濕度、雜質含量(包括液體內容、固體含量和直徑、硫、苯、苯酚、焦油、年平均氣溫、氣溫、氣溫、海拔高度等。

　　: when selecting natural gas generator set, gas generator users shall select appropriate gas source according to local resource conditions, and then determine relevant physical parameters and gas environment state parameters based on gas composition analysis and calculated low calorific value gas, Such as gas composition, flow, pressure, temperature, relative humidity, impurity content (including liquid content, solid content and diameter, sulfur, benzene, phenol, tar, annual average temperature, maximum temperature, minimum temperature, altitude, etc.).

　　注:燃氣機組對燃料成分有嚴格要求。因此，選擇時間太長，需要的測試。根據瓦斯發熱量和瓦斯體積，估算出單位功率。

　　Note: gas turbine has strict requirements on fuel composition. Therefore, the selection time is too long, which requires professional testing. According to the calorific value and volume of gas, the unit power is estimated.

　　5. 啟動時間

　　5. Start time

　　柴油發電機組:3- 15秒

　　Diesel generator set: 3-15 seconds

　　氣體發電機組:至少30秒

　　Gas generator set: at least 30 seconds

　　6. 安全

　　6. Safety

　　柴油發電機組:柴油穩定性高，易于儲存。

　　Diesel generator set: diesel has high stability and is easy to store.

　　燃氣發電機組:天然氣的主要成分是甲烷，與其他一些氣體混合在一起，穩定性較差，如果有泄漏或與空氣接觸達到一定比例，就會(huì )發生爆炸，對儲存設備有要求。

　　Gas generator set: the main component of natural gas is methane, which is mixed with other gases and has poor stability. If there is leakage or contact with air reaches a certain proportion, explosion will occur, which requires storage equipment.

　　7. 安裝周期

　　7. Installation cycle

　　柴油發電機組:一般8 ~ 20天

　　Diesel generator set: 8-20 days in general

　　燃氣發電機組:至少兩個月，天然氣供應系統需要人員和設備進行檢測、壓力檢測、泄漏檢測等必要的檢測。

　　Gas generator unit: at least two months, the natural gas supply system needs professional personnel and professional equipment to carry out necessary tests such as detection, pressure detection, leakage detection, etc.

　　8的優勢。

　　8.

　　柴油發電機組:

　　Diesel generator set:

　　(1)當燃油經濟性、高熱效率和工況變化時，燃油消耗率曲線變化較為平緩，在低負荷下也較為經濟

　　(1) When the fuel economy, high thermal efficiency and working conditions change, the fuel consumption curve changes more smoothly and more economically under low load

　　(2)可靠耐用。由于沒有點火系統，故障率很低

　　(2) Reliable and durable. Low failure rate due to no ignition system

　　(3)使用范圍廣

　　(3) Wide range of use

　　(4)降低有害排放

　　(4) Reduce harmful emissions

　　(5)消防安全良好

　?。?） Good fire safety

　　(6)啟動快，可快速達到全功率只需幾秒鐘，緊急情況下1分鐘內帶滿負荷失效(正常5~30MIN)關機過程短，可頻繁停機。

　　(6) Fast start, can quickly achieve full power in just a few seconds. In an emergency, the shutdown process with full load failure (normal 5-30min) in one minute is short and can be stopped frequently.

　　(7)維修操作簡單，人員少，待機期間維修方便

　　(7) Simple maintenance operation, less personnel, and convenient maintenance during standby

　　(8)柴油發電機組的建設和發電的綜合成本

　　(8) The construction of diesel generator set and the comprehensive cost of power generation are the lowest

　　燃氣發電機組:天然氣儲量豐富，價格低廉。但是它需要很長時間的使用。

　　Gas generator set: rich in natural gas reserves and low in price. But it takes a long time to use.

　　以上是燃氣發電機組廠家為大家介紹的相關內容，想要了解更多內容，歡迎訪問網站：http://m.elmasticar.com

　　The above is the relevant content introduced by the gas generator unit manufacturer. For more information, please visit the website: http://m.elmasticar.com